Product ID:AMPVAR PRIMER BASE, 0340703
MSDS Date:07/23/1991
FSC:8010
NIIN:00N037520
MSDS Number: BQVTM

ATLAS MINERALS & CHEMICALS INC

FARMINGTON RD
MERTZTOWN, PA 19539-0038
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 215-682-7171

Cage: 04503

ATLAS MINERALS & CHEMICAL INC

MERTZTOWN, PA 19539-0038 US

Telephone: 215-682-7171

Cage: 04503

43 @ 68F.

CAS: 64-17-5

RTECS: KQ6300000

Fraction By Weight: 55-65%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM

BUTYL ALCOHOL; (BUTANOL)

CAS: 71-36-3

RTECS: EO1400000

Fraction By Weight: 15-25%

OSHA PEL 100 PPM

ACGIH TLV: S, C 50 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

CHROMIC ACID, ZINC SALT; (BASIC ZINC CHROMATE)

CAS: 13530-65-9

RTECS: GB3290000

Fraction By Weight: 5-10%

OSHA PEL 0.1 MG/M3 (CRO*3)

ACGIH TLV: 0.01 MG/M3 (CR)

27360-07-2

CAS: 108-05-4

RTECS: AK0875000

Fraction By Weight: 8-12%

OSHA PEL 10 PPM/15 STEL

ACGIH TLV: 10 PPM/15,A3 STEL;93

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

SILICA, AMORPHOUS FUMED; (AMORPHOUS SILICON DIOXIDE)

CAS: 112945-52-5

RTECS: VV7310000

Fraction By Weight: 1-2%

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: CONTACT CAUSES
IRRITATION. MAY CAUSE BURNS, TEARING, REDNESS OR SWELLING. SKIN:
CONTACT MAY CAUSE IRRITATION. PROLONGED OR REPEATED EXPOSURE MAY
CAUSE REDNESS, BURNING, DRYING AND CRACKIN G. INHALATION: RESULTS
IN IRRITATION TORESPIRATORY TRACT AND MUCOUS TISSUES. MAY ALSO
CAUSE NAUSEA & (EFTS OF OVEREXP)
Explanation of Carcinogenicity:ZINC CHROMATE: GROUP 1 ,IARC MONOGRAPHS,
VOL 49, P.49, 1990. KNOWN CARC, NTP SIXTH ANNUAL RPT ON
CARCINOGENS,1991.
Effects of Overexposure:HLTH HAZ: DROWSINESS. INGESTION: CAUSES
DIZZINESS, DROWSINESS, DECREASED REACTION, EUPHORIA, NAUSEA,
VOMITING AND VISUAL DISTURBANCES. CHRONIC: MAY CAUSE RESPIRATORY
AND DIGESTIVE TRACT IRRITATION, NE RVOUS SYSTEM DEPRESSION.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN,
RESPIRATORY, KIDNEY AND/OR BLOOD DISORDERS.

First Aid:EYES: FLUSH WITH CLEAN WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION. SKIN: WASH CONT AREA W/MILD SOAP & CLEAN WATER
IMMED. REMOVE CONTAMD CLTHG & SHOES. DO NOT REUSE UNTIL LAUNDERED.
IF IRRIT PERSISTS/SKIN BURNS DEVELOP, GET MED ATTN. INHAL: REMOVE
VICTIM TO FRESH AIR. IF BRTHG STOPS BEGIN ARTF RESP. GET MED
ATTENTION. INGEST: GIVE VICTIM 2 GLASSES OF WATER & INDUCE VOMIT.
GET MED ATTN.

Flash Point Method:TCC
Flash Point:54F,12.2C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . COOL SURROUNDING AREA WITH WATER.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.

Spill Release Procedures:IF OUTSIDE, STAY UPWIND OF SPILL. IF INSIDE
VENTILATE AREA. AVOID RUNOFF INTO NATURAL WATERWAYS. USE ABSORBENT
MATERIAL SUCH AS CLAY, SAND OR DIATOMACEOUS EARTH. ELIMINATE ALL
SOURCES OF IGNITION. PLA CE IN NON-LEAKING CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:AVOID STORAGE IN SUNSHINE. STORE IN A
COOL, DRY PLACE. KEEP AWAY FROM HEAT, SPARKS AND FIRE.
Other Precautions:AVOID PROLONGED OR REPEATED CONTACT WITH SKIN. DO NOT
TAKE INTERNALLY. FOR INDUSTRIAL USE ONLY. KEEP OUT OF REACH OF
CHILDREN.

Respiratory Protection:USE A NIOSH/MSHA APPROVED RESPIRATOR IF TLV IS
EXCEEDED OR USED IN CONFINED AREAS.
Ventilation:LOC: PROVIDE ADEQ VENT TO KEEP EXPOS BELOW TLV.EXHST SOLV
FUMES FROM NEAR FLOOR.MECH ACCEPTABLE,BUT MUST BE EXPLO-PROOF.
Protective Gloves:PLASTIC OR RUBBER GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.

Boiling Pt:B.P. Text:ING 1
Vapor Pres:ING 1
Vapor Density:HVR/AIR
Spec Gravity:0.89
Evaporation Rate & Reference:FASTER THAN BUTYL ACETATE
Solubility in Water:PARTIALLY SOLUBLE
Appearance and Odor:OLIVE COLOR LIQUID WITH CHARACTERISTIC ODOR.
Percent Volatiles by Volume:85-90

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS AND FIRE.
Hazardous Decomposition Products:ALDEHYDES, OXIDES OF ZINC AND
CHROMIUM, CARBON MONOXIDE AND/OR CARBON DIOXIDE.

Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE AND FEDERAL ENVIRONMENTAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.